Volvo Penta D2-75 service schedule
Inboard diesel ·
25 maintenance items for the Volvo Penta D2-75. The engine oil is changed every 500 h or 12 months. When an item has both an hour and a calendar interval, the one that comes first applies.
| Item | Engine hours | Calendar | Rule |
|---|---|---|---|
| Before the first start of the day: visual inspection, engine oil level, coolant level | — | before each use | |
| Drain water and sediment from the fuel pre-filter | — | every 14 days | |
| Check the drive belt tension and condition | — | every 14 days | |
| Check and clean the seawater filter | — | every 14 days | |
| Check the battery electrolyte level | — | every 14 days | |
| Check the reverse gear or S-drive oil level | — | every 14 days | |
| When laid up afloat: run the engine to operating temperatureCalendar task while the boat is laid up afloat; inhibit the engine if it will not run for more than two months.Only on some variants or when laid up | — | every 14 days | |
| Clean and inspect the folding propeller | — | every year | |
| Check the S-drive rubber seal | — | every year | |
| Change the reverse gear or S-drive oil | every 200 h | every year | whichever first |
| Change the reverse gear oil filterReverse gears fitted with an oil filter. | every 200 h | every year | whichever first |
| Lubricate the propeller shaft seal | every 200 h | every year | whichever first |
| Check the corrosion protection (anodes) on the drive and the engine | every 200 h | every year | whichever first |
| Change the engine oil and the oil filter | every 500 h | every year | whichever first |
| Change the fuel filter and the fuel pre-filter element | every 500 h | every year | whichever first |
| Check the idle speed | every 500 h | every year | whichever first |
| Check the seawater pump impeller; replace if worn | every 500 h | every year | whichever first |
| Check the vacuum valve | every 500 h | every year | whichever first |
| Replace the air cleaner | every 500 h | every 2 years | whichever firstDealer |
| Change the coolant | every 500 h | every 2 years | whichever firstDealer |
| Clean the heat exchanger and the charge air cooler | every 500 h | every 2 years | whichever firstDealer |
| Check the fuel injectors | every 500 h | every 2 years | whichever firstDealer |
| Check and adjust the valve clearances | every 500 h | every 2 years | whichever firstDealer |
| Replace the propeller shaft seal | every 500 h | every 5 years | whichever first |
| Replace the S-drive hull seal | — | every 7 years | Dealer |
Free in Voydar Helm: each interval becomes a maintenance task, due by hours or by date, whichever comes first.
Source
Volvo Penta D2-55 / D2-75 operator’s manual, maintenance schedule chapter
Read from the maker's manual.
Revision read: Edition as publicly hosted (noshoes-resoled.com, 2020-02 upload); read 2026-10-12. Revision code not recorded: confirm against the current manual for your serial number.
Reference only. Intervals vary by serial number, use and climate; your engine's current manual and your dealer are the authority. Part numbers and diagrams are in the manual.